<strike id="mmadl"><bdo id="mmadl"><s id="mmadl"></s></bdo></strike>

產品展示中心

直燃式焚燒爐(TO)Direct-fired Incinerator TO

適用于小風量、高濃度、高溫的有機廢氣處理

                                Suitable for treatment of organic waste gas with low air volume, high concentration and high temperature


工藝流程 Technological process


1504754164652948.jpg


系統簡介System introduction



TO系統采用天然氣助燃,將小風量、高濃度的有機廢氣直接燃燒,在750~850℃的高溫狀態下,有機物會分解成無害的CO2H2O,同時放出大量熱量,化學反應方程式如下:

TO system uses natural gas as combustion-supporting agent and combusts organic waste gas with low air volume and high concentration directly. Under the high temperature of 750-850, the organic matter will be decomposed into harmless CO2 and H2O, while releasing a large amount of heat. The chemical reaction equation is as follows:



3.jpg


經燃燒后的高溫煙氣(≥800℃)通過管式換熱器,與新進的有機廢氣對流換熱,新進的廢氣被預熱,煙氣溫度被降低(≤550℃),此時由于煙氣溫度仍然較高,如直接排放將大大浪費能源,所以TO系統后都會組合煙氣熱風爐或者煙氣熱水爐,用于回收高溫煙氣中的熱量,整套熱能回收利用系統被稱之為TNV系統。

After combustion, the high temperature flue gas (≥ 800) transfers convection heat with the new organic waste gas through the tube heat exchanger, the new waste gas is preheated, and the flue gas temperature is reduced (≤ 550 ). At this time, as the flue gas temperature is still high, such direct emission will greatly waste energy, the TO system will be combined with hot air stove or hot water stove to recover the heat in high temperature flue gas. A whole set of heat energy recovery and utilization system is called TNV system.


注意事項 Notice


需要保證廢氣中含氧量>19%

       It is necessary to ensure that the oxygen content in exhaust gas is more than 19%.

進氣有機物最大濃度為25%LEL

       Maximum concentration of intake organic matter is 25% LEL

裝置后需配套熱能回收裝置

       Thermal energy recovery device is required after the installation.


系統優勢 System advantage


設備凈化效率極高,≥99%

       Equipment purification efficiency is very high, (≥99%)

設備使用壽命長

       Long service life of equipment

占地面積小、重量低

       Small footprint and low weight

耗材少,設備維護量低

       Less consumables, low maintenance of equipment

TNV系統可實現熱能回收利用

      TNV system could realize heat energy recycling and utilization



 

上一篇:催化燃燒裝置(CO)

下一篇:紫外線(UV)光氧裝置

相關新聞

news center

  • 04

    25

      有機廢氣處理設備是工業中進行廢氣處理必不可少的一種設備,有機廢氣處理設備憑借著其外箱結構一體化的個性設計,加以優質鈑金烤漆工藝,能夠實現高強度、抗沖擊性好的突出性能。那么,除此之外,有機廢氣處理設...

  • 04

    18

      石油化工過程以及各種使用有機溶劑的行業,如噴漆、印刷、制藥、煤化工等,排放的最常見的污染物“揮發性有機化合物(VolatileOrganicCompounds,簡稱VOCs)”,目前已經成為環保行業去除的焦點。該類化合物多數...

  • 04

    17

      合成革即模擬天然革的組成和結構并可作為其代用材料的塑料制品,中國合成革產業巨大,其生產工藝有“干法”和“濕法”,會產生大量的廢水和廢氣,在環保被日益重視的今天面臨一系列問題?! ≈聘锷a工藝中加入...

  • 04

    10

      目前很多企業對VOCs治理的認知度不高,且因為治理前期的投入較大而產生的經濟效益難以收回成本,致使治理的難度增大。但是為了更好的發展,不能因為有困難就臨陣脫逃,迎難而上才是正確的選擇。為了能夠更好的做...

>
黄大仙射箭另 泰兴市| 得荣县| 林周县| 潮州市| 恭城| 称多县| 海门市| 建昌县| 武宣县| 凤阳县| 建湖县| 三河市| 富裕县| 儋州市| 甘谷县| 枝江市| 星子县| 桦南县| 左贡县| 根河市| 德令哈市| 任丘市| 获嘉县| 禄丰县| 甘谷县| 灌阳县| 二连浩特市| 威远县| 万宁市| 武乡县| 临沂市| 鞍山市| 曲松县| 江华| 涟水县| 闽清县| 将乐县| 吉林省| 陇西县| 中江县| 渝中区| http://v.lsjf5b.club http://m.lsjo1o.club http://tv.101kyy.top http://www.ableworld6.cn http://www.lsj526.pw http://www.douban.com/note/719460886/